I had my flexplate fail twice within 12500 miles of each other. Even the automaker discusses the trouble with the voice prompts with Service Bulletin #SSM 48336. On 1 other occasions january 1st 2020 the car was in my driveway stationary. Ford Fusion owners have reported 3 problems related to computer failure (under the electrical system category). I should be able to see for at least a half second to tell if I am driving within my lane. Chevy sent me to ford, ford wants my extended warranty to pay for it. Ford said glass is not covered under warranty. I was replacing the pads required about $280 on repair costs. The contact stated while driving 65 mph, she heard abnormal bubbling sounds coming from the engine before the vehicle stalled. 2017 Ford Fusion Engine Computer Control Module ECU 72K Miles OE (LKQ~328389851) Sponsored. The code was p0456. The vehicle then independently turned to left and hit the barrier wall on a bridge without warning. It cracked while I was driving and no service or warning lights turned on. Additionally, the dealer diagnosed that the transmission needed to be replaced. After doing some research online I've seen so many people with my same car reporting the same issue. Description: FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. I think I bought a lemon. All the air bags deployed except for the front driver side and steering wheel air bags which failed. 2016 FORD Fusion Recalls, Complaints and Investigations - The Center for Auto Safety Home / Vehicle Safety Check / 2016 FORD Fusion 2016 FORD Fusion Subscribe to alerts for a 2016 FORD Fusion These recalls apply to the make, model, and year of your car - and should be fixed as soon as possible. January 23rd called the scheduled another appt for january 29th. The vehicle was not repaired. The manufacturer was also notified of the failure and was referred to nhtsa for assistance. My ford fussion has a cracked flex plate. Now my car shakes and the overheating light stays on. The contact owns a 2019 ford fusion. According to user reports, the Ford Fusion tends to burn through oil as you rack up the miles. 2022, CarProblemZoo.com All rights reserved. I didn't see the deer standing on the side of the road until I was almost next to it, the high beams were on. The dealer informed the contact that he would be responsible for the cost of the repair. The cure for the common car is one that actually works the way owners want it to. The contact stated that the vehicle started after approximately five minutes with the check engine warning light illuminated. One of our staff members will call you shortly. I was in a car accident that ultimately totaled the car. The vehicle was repaired but the failure had reoccurred. The vehicle had not been taken to the dealer. The headlights on the 2019 ford fusion are horrendous! You can see the diagnostics for this concern, below, step one is to get the codes. See the jurisdictions in which our lawyers are licensed, admitted, or otherwise authorized to practice. I also informed the attendant when I returned the car at atlanta airport today. Instead, they require that the engineers spend a little more time figuring out what is wrong. The contact owns a 2019 ford fusion. 2018. Its been over a month. If it does, I'll be capped off and still have to come up with 00!! Confidentiality Guarantee: We keep your information completely confidential and will not send you spam or sell your information. I was driving a avis rental car - ford fusion 2019 in an interstate from chattanooga, tennessee to dalton, georgia. As the contact pulled the vehicle into a parking space and placed the gear into Park, the engine revved three times. Fusion traveling northbound and t-boned sedan traveling westbound in intersection. The manufacturer had yet to be notified of the failure. With cruise control set, pressing the + button and holding for a few seconds to increase the speed a few mile per hour will cause the vehicle to continue accelerating until the 'cancel' button or the 'off' button is pressed. In process boke a spark plug that was replaced at no charge. The vehicle was unable to be driven. The site declared the 2011 Fusion as the worst because it has higher repair costs and problems that appear at a lower mileage count. When the fuel pump is bad, it will not send any fuel to the engine; therefore, the fuel tank will stay filled, and the engine will not start. Free shipping. I was told that I could take the car home while they reached out to ford to see if they were willing to cooperate in taking care of the cost of repair, that the car was safe to drive and was only burning off a tiny bit of coolant when starting. The contact stated that her daughter was driving at 45 mph, the vehicle began to pull to the left as an abnormal noise began emitting from the vehicle. He towed the car to tropical ford, orlando fl. The modern vehicles electrical system runs every aspect of todays cars. Check engine light came on may 3 at 11am. Ford filed a motion to dismiss the lawsuit and U.S. District Judge Lucy H. Koh agreed to do just that. They've changed the battery thinking it would help hit it didn't. Haven't had the car a year and a half. At 1,193 complaints, steering issues make up nearly half of the 2,469 total complaints on file with the NHTSA for the 2011 Ford Fusion. I called avis roadside assistance immediately on return to hotel and asked them to record this issue. The manufacturer was not notified of the failure. Airbag light came on and took the car to dealership and they denied to cover airbag module replacement under warranty. The failure mileage was approximately 22,000. So 2 days after getting my oil changed at a dealership my car began to overheat which shouldn't have happened because when I got my oil changed they filled the liquids to proper levels. I had it towed to pepboys who did a full diagnostic and provided documentation saying I'd need a new engine. The vehicle was not repaired and remained at the dealer. 2006 2007 Ford Fusion Engine Computer . Imagine this was tire issue, nothing about the steering. The failure mileage was 58,000. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. Partially dismissed March 2015. that's The vehicle is presently being looked at by the dealership where it was bought. Aside of that, the adaptive cruise control feature is inconsistent in detecting vehicles while switching lanes or in flat surfaced curves, regardless of the weather (happened multiple times during clear days and under moderate rain). T o whom it may concern, thank you for assisting me during this process. The tire has a nail in it and is flat. . Hooked up computer and ran car for 20 minutes looking for anything unusual, no problems found. 2013 Ford Fusion Transmission Problems and Repair Descriptions at TrueDelta 2013 Fusion Problems o Engine (19%) Transmission (11%) Brakes (4%) Suspension (6%) Electrical and AC (36%) Body and Trim (19%) Other (6%) Select a problem area Transmission and Drivetrain Chart based on 338 repairs. Once it turned off. The engine short block was replaced; however, the contact stated upon starting the vehicle three months later, she heard abnormal knocking sounds coming from the engine. The speed sensor replacement and several unknown repairs were completed; however, the failure persisted. While there dealer asked several questions concerning specifics; like, is coolant leaking from your engine and is it visible on the ground; husband said no. January 21st, car into service to reprogram power train /cleared all codes. Extreme temperatures can also be involved here. The reason I'm so upset with this is because 2-3 times it's happened to I've had my toddler with me and in order for me to go (when the car should automatically turn on once I remove my foot from the break), I have to turn off my car and turn it back on and it's happened during traffic and bug interactions. This app was the very best of many apps yet ford recently said the AT &T no longer supports 3g so Ford said you dont have to but if you would like an app you need to go to a dealership to replace the 3g modem over to a 4g modem to have another different app called Ford Pass. But I feel this is a defect and will be going back to my dealer ASAP.. The manufacturer was notified of the failure. Select Radio. With only the check engine light on I waited 10 minutes and the car started. 2017 Ford Fusion; Outside air temp read -40; A/C inside was blowing hot air (with the A/C button on) I have a 2017 Ford Fusion Titanium. I started the car manually car would not start (no engine turn over) but car start stop button would be green as if car was running. It started to roll out my driveway after putting it in park. There's no telling how many accidents this has cause and or will cause in the future. My question to them was; why would ford make a new block for the same engine if there was never a factory problem with the original block? The repair shop said the flex plate is cracked and it's a common issue with ford. The vehicle was then taken to the dealer where it was confirmed that the lug nuts needed to be replaced. My 2019 fusion, cuts off in traffic. The contact stated that while driving at various speeds, the trunk inadvertently unlocked and opened. The manufacturer and local dealer were notified of the failure. If the sensor was told that the battery was only 1 year old (over riding the system), the . The contact mentioned that the information provided were based on pictures and videos of the events of the impact due to him having memory loss. The manufacturer was notified of the failure but provided no assistance. There is no visible leak and I don't know where the antifreeze goes. The vehicle was diagnosed at the residence by an independent mechanic as a shifter cable failure. How Does the CFPBs Debt Collection Rule Affect You? The contact spoke with the dealer manager and they finally agreed to let the contact lease a new vehicle; however, they rolled over the other lease into the new vehicle, which doubled the monthly payments. If it blows a fuse again, you need to have the electrical system troubleshot. The trunk came open while driving on a street and busted the back windshield out. James D., IL (2016 Ford Fusion Titanium 2.0-L 4 Cyl turbo) Rough . I continued to add coolant every now and then. In addition, the dealer later stated that the computer failed and needed to be replaced. No airbags deployed in fusion. it likes to go up to 4k before shifting unless i take off really really slow. 2019 Ford Fusion Hybrid Titanium Four-Door Sedan In .Tires that have been punctured and repaired with a string plug may hold air . The vehicle was towed twice to two different independent mechanics. Failure of airbags to deploy likely cause sternum fracture. The failure mileage was 80,000. It is located in the gas tank and this unit knows to break and make the car not start. 2010 Ford Fusion "Service Power Steering Now". $101.84. There is no charge unless we win. Fix A Flat Tire: Ford Fusion (2010-2012) - 2010 Ford Fusion SE 2.5L 4 Cyl. The mechanic performed a pressure test on the vehicle and the contact was informed that there were no leaks inside the vehicle. Ford Fusion owners have reported 3 An audio message will play & SYNC will start rebooting to update. The manufacturer was notified of the failure and the contact was advised to call the nhtsa hotline, but no further assistance was provided. Tl* the contact owns a 2019 ford fusion. In all three complaints reviewed above, it shows that the Fusion failed before hitting 500 miles on the odometer. If my trunk were to open while I was driving the distraction would put myself and other drivers at risk. 10 Images about 2006 Ford Escape Problems - Greatest Ford : 2007 2008 2009 Ford FUSION Engine Control Module ECU REPAIR KIT SERVICE, 2010 Ford Fusion PCM 3.5L - ECM ECU Programmed & Updated | Flagship One and also 2006 Ford Escape Problems - Greatest Ford. The manufacturer was not made aware of the failure. Upon discussion of the issue with a friend, he said he had the same exact issue with a 2015 fusion. The answer is simple. This is nearly a 00 job. The contact stated that the vehicle had experienced multiple electrical/computer malfunctions that included the front windshield wipers randomly activating and bouncing up and down. The vehicle had not been repaired. One reason is a weld issue with the lower control arms. The vehicle was not repaired. I have this car the computer is bad just all the ones I seen it is a 2008 Ford Fusion sel it shuts everything down. On the 16th of april I had a local shop inspect it, but all they could do was disconnect the release latch. The contact stated that while driving at various speeds, the vehicle experienced random hesitation and stalling with the check engine warning light illuminated. I took the car dealership. Engine light was addressed promptly and coolant error message showed up once ever when the car abruptly stalled in the middle of highspeed traffic ford refused to help after escalation attempt to have them pay for faulty product or lemon buyback. This further proves how right the tagline cure for the common car actually is. fusion ford tire se fuse location tires steering power brake flat 5l cyl jack box manual interior check change fix. One of the most common problems is a 2016 Ford Fusion steering assist fault. Replace any blown fuses and monitor the system. The following day the contact went back to the scene and found the passenger front axle on the road. We are Lemberg Law, a Consumer Law Firm. The transmission may have a hard time shifting, or not even be able to shift at all. This is unsettling at the least, dangerous at its worst. In the meantime, you are welcome to call us right away at 855-301-2100. Tl* the contact owns a 2019 ford fusion. We have had this same issue happen to three of our 2019 fusion's (company cars). Car kept stalling and running hot. The manufacturer was notified of the failure; however, provided no assistance. The failure had occurred approximately 6 times within a month. Vehicle Type: Midsize Sedan. The failure occurred twice and the speed reached exactly 71 mph. We want to keep you up-to-date with the latest software for your Ford. When I was finally able to pull off the road safely, I opened my hood and found that my coolant reservoir was completely empty. Holden Commodore VN to VT > ECU codes & Procedures The Holden.Westinghouse, a major global corporation that makes electronics, lighting and supplies power, offers both consumers and businesses an enormous array of . The contact owns a 2019 ford fusion. *ln *jb *tr, 2019 ford fusion. Call our Helpline today! Now that it is out of warranty they refuse to cover this ongoing issue. Read this NHTSA complaint. After searching for days, I finally got one to do the diagnostic and said there is an issue with the coolant destroying the engine. See It was a seven-vehicle collision. Yesterday when this happened, my car was charging at a public charging station. The manufacturer was made aware of the failure and a case was opened. In the event of a crash, heat from the deployment of a seat belt pretensioner may cause a front seat belt. Upon releasing the brake pedal, the vehicle accelerated on its own at a high rate of speed. 2017. The vehicle was not yet repaired. The contact stated that the coolant level was below the minimum mark when the vehicle was purchased. Other vehicle was totaled. You may then release the buttons. problems related to computer failure (under the electrical system category). Twice, when I went to buckle the driver-side seatbelt, the end went not into the latch, but instead into the casing around the latch (see pictures). The manufacturer was notified of the failure and the contact was directed to call the nhtsa hotline. The manufacturer was not notified. 1. The failure mileage was 77,000. He asked me if there was a check engine light on or if the car heated up at any moment. As a result, the engine needed to be replaced. I reached down on the right side of the driver's seat to retrieve a fallen object and cut my wrist on a sharp, raw, metal edge of a stamping on the side of the seat. 2020. This particular model suffers from a faulty electrical system, defective engine and dangerous vehicle speed control system. The contact stated that the vehicle was taken in for an annual inspection but failed due to the lug nuts. When the day after I got my car back the check engine light came on and I took it back to the dealer. They did not go fast enough to clear the water from the windshield so I could see the road. I was probably almost stopped before the car rapidly accelerated for no reason! Free shipping. The dealer justified this by stating that no failure was found with the first vehicle and blamed the contact. The contact was able to veer to the side of the roadway. The failure occurred twice and the speed reached exactly 71 mph. The contact stated that while operating the vehicle, the steering wheel was loose and would move up and down. The vehicle was taken to the local unknown dealer who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not repaired. It occurs when the electronic power steering assist system malfunctions, and the assembly has to be replaced. http://circuitboardmedics.com/ford-fusion-pcm-repair/This is a Ford Fusion PCM (Powertrain Control Module) repair service for a 2006, 2007, 2008, or 2009 For. The contact stated that the vehicle was making a rattling noise coming from the engine compartment while idling. The dealer informed the contact that the flywheel needed to be replaced. Jft. Tl* the contact owns a 2019 ford fusion. Or, instead you can send a secure message to our legal team. Took to dealership and was told that the short block had to be replaced to to coolant leaking into #2 cylinder from a crack. The approximate failure mileage was 35,000. The contact's daughter and son were transported by ambulance to the hospital for injuries sustained. The contact indicated that the transmission had been rebuilt on three separate occasions. We found that this is well known issue on this but ford never told us about it. I have a video of the incident but I can not attach it. Dealer advised there is a tsb on this and it is a common problem with the engine. The contact stated that the front driver's side suspension fractured and caused the front driver's side wheel to make contact with the inner wheel well and seize in place. The dealer told me that since there was no check engine lights on it was something normal. 2 phone reps and their supervisor repeatedly said there is nothing they can do, told me it is normal wear and tear, and there is no other phone number or department I can contact to further pursue this issue. The manufacturer was not made aware of the failure. Https://www. As a result, the contact lost control of the vehicle and the vehicle could not be turned to the left or right direction. The contact owns a 2019 ford fusion. As the contact pulled the vehicle into a parking space and placed the gear into park, the engine revved three times. MODELS 2003-05 THUNDERBIRD Want to learn how to fix NHTSA #10048099? The contact stated that after topping off the coolant and driving for a while, the coolant level was again below the minimum level. This causes the vehicle to accelerate so it returns to the set speed. The dealer is putting air i n the tire and calling it good. sean.smith September 3, 2014, 2:50am #1. The approximate failure mileage was 20,000. The failure mileage was 20,000. The contact was informed that the damage was caused due to improper manufacturing of the engine in which two different types of metals were used causing the engine to cool down at different rates. The approximate failure mileage was 70,000. The vehicle was towed to a tow truck company. . Sadly, the Fusion cant provide this simple functionality, making it a lemon. 2012 Ford Fusion Edit Common Problems & Repairs Near 98848 5 Recalls Found To see if your specific car is affected, enter your VIN. Hold the Power button (center of the volume knob) + the Right-Seek button at the same time for approximately five seconds. The manufacturer was not contacted as of yet. Here are the 5 main problems with the Fusion - YouTube 0:00 / 8:35 Here are the 5 main problems with the Fusion 54,940 views May 3, 2018 155 Dislike Share Save Driven Companion 37K subscribers This makes the car quite hard to maneuver and causes immediate safety risks. I went to the dealership and they even said it happens all the time. The manufacturer assigned a case number and manager to the contact. 3 weeks after I leased the vehicle new, the windshield shattered without anything hitting it. Have you had a bad experience too? i've only had it 2 months and have put less than 3000 miles on it. The problem has been confirmed by an independent service center and was also inspected be the independent service center. The steering wheel becomes slightly sticky and loses power assist slowly. Overall the worst problem category is Ford Fusion steering problems. Along with the engine, the vehicle speed control is malfunctioning and putting users in danger. Landmark Supreme Court Decision Made in Lemberg Laws Facebook Robocalling Suit, Lemberg Law Wins Class Certification in Robocall Case, I bought a 2022 Camry LE back in January of 2022. 2011 Ford Fusion. I saw an error message on the screen all of a sudden (like communication error) and the engine just shut off, all lights turned off and seat started moving back. The vehicle was not repaired, but an appointment was scheduled for april 9, 2019. It is reading that I have a faulty purge valve. 78250 miles, premium gas, annual premium treatment at oil changes with royal purple, schedule a tuneup with diagnostic, new tires, wash tub monthly cleans. Additionally, the steering wheel became difficult to operate. There are no codes stored for any vehicle that state clear the code and the concern is resolved. Likely to be the fuel pump. The steering wheel moves up and down, also the the steering wheel moves left to right. Additionally, he had no access to any safety system in the event of a crash. The fusion was started less than 5 minutes prior to accident and driver received message indicating the front camera was unavailable. $95.71. What is my recourse as I am concerned about the value and reliability of my vehicle going forward. Ford Fusion - (photo-denver / Shutterstock) The most common causes for Ford Fusion shaking at high speeds are unbalanced wheels, misaligned wheels, tire damage, bent rim, bad wheel bearing and loose lug nuts. No further information was available. The contact refused to take the vehicle back and threatened to make no more payments on it even if it ruined her credit. The failure mileage was approximately 52,500. Perform a soft reset. I have 69,400 miles on my car. Check out our Ford Fusion overview to see the most problematic years, worst problems and most recently reported complaints with the Fusion. 2019 Ford Fusion Energi-Titanium was purchased brand new with my ford mobile app from one of their dealerships. I needed my car asap. The vehicle was towed to the dealer, but no failure was found. The contact stated that several attempts were made to restart the vehicle, but the engine failed to turn over. Html, I bought this vehicle in 2019 and one of the engines cylinders was crack and now I need a new engine and I heard that this a very common problem with this vehicle. The failure mileage was approximately 56,000. This morning I googled ford fusion trunk opening by itself and saw multiple online forums with other ford fusion owners, who going back years, have been experiencing their trunks opening for no apparent reason. The contact's daughter owned a 2019 ford fusion. Car left again at the shop at 1-29-2020 5:45. The failure mileage was approximately 28,000. All airbags deployed in other vehicle. Ford knows of this issue but does not take responsibility for the issue if the vehicle is no longer under warranty. The contact owns a 2019 Ford Fusion. The car is sitting there. About a week or so ago I went out to crank my car and it sounded awful it was shuttering, sounded like it was going to shut off and the engine light came on, it's a 2019 ford fusion. Holden Rodeo 1988-2002 Factory Service and Repair Manual Commodore VZ . My head and face hit the windshield leaving me with injuries to my face and nose and I had injuries on the entire left side of my body. Schedule Service Contact Us Find a Dealer The vehicle was in my driveway stationary. There were no warning indicators illuminated. Prior to recall notice; on 12-20-19 husband noticed coolant l level down at approximately 7,000 miles. I then took it to the dealership for further inspection and diagnosis. statistics and reliability analysis of Ford Fusion based on all problems reported for the Fusion. Customers shouldn't have to wrestle with their vehicles on the road. A police report was filed at the scene. an oil change was done a few days before i bought it. statistics and reliability analysis of Ford Fusion. The contact owns a 2019 ford fusion energi. The vehicle was towed to [dealer] but was not diagnosed or repaired. Also please check out the That is unacceptable. My speakers will crackle loudly and won't stop until the car is off. All of a sudden my vehicle just stop , brakes became too stiff to turn back the vehicle as you are suppose to press the brake and push the start button. Retuned home with coolant and filled the reservoir. The vehicle was taken to the dealer where it was diagnosed with a cracked flywheel. After 40- 60 min the car showed it was going to turn off in 15 min to save power. After dealer inspection, advised on may 5 that coolant leak into cylinders is requiring a new engine at 28,700 miles. Ford states that some vehicles suffer from skipping, hiccups or short pauses while information is provided, yet they dont have a fix yet. No warning light was illuminated. The guy who was in the passenger seat pushed the start button and it started and I managed to drive last 5 miles to reach hotel. Unbalanced wheels. There is very little visibility, I'm constantly having to turn on my brights to even see some aspects of the road I'm on. 2017 Ford Fusion Engine Computer Control Module ECU 40K Miles OE (LKQ~304338147) Driver of fusion, wearing seatbelt, suffered sternum fracture. The vehicle was taken to rod baker ford sls inc (16101 s lincoln hwy, plainfield, il 60586) on approximately ten separate occasions where the contact was provided different diagnostic information each time the vehicle was brought in. Product Description. The Fuel Pump Is Broken. In case of failure, you can try this: Give a few blows on the front (the pointed part) of the starter . Conclusion: Ford Fusion Bad PCM Symptoms The vehicle was towed to the dealer where it was diagnosed that coolant had been leaking into the engine and had caused the engine to fail. Regular vehicles will last more than 100 miles and dont try to hold on to maintenance parts that should be removed. The vehicle was taken to a local dealer where it was diagnosed with needing the engine replaced. The first time I just turned off the car and waited about 5 minutes, it resolved itself. No, my car never heated up and there was never a check light on. This problem occurred mostly at vehicles around 80,000 miles. Free shipping. If yes, confirm if it was taken for a fix. Day after coil ignition and spark plug replacement, engine light came back on which mechanic said not to worry as long as car isnt shaking. Does this ring a bell? *tr*dt*jb. This makes a few times now where I have parked my car and left, then when I returned my trunk was open. Collision at 35mph front end of fusion hit the entire passenger side of another vehicle . I took it into a dealership and eventually it was discovered that the computer sensed the battery to be over 9 years old and instructed the hybrid system not to work. The contact managed to drive the vehicle home. The failure mileage was approximately 70,000. A Ford Focus and Fusion electronic power assisted steering (EPAS) lawsuit won't be certified as a class-action after a judge ruled the plaintiffs can't prove all owners experienced harm from the alleged defect. The failure mileage was 65,000. Washing the front windshield and noticed a hairline crack on the outside about 4-5 inches long. The contact owns a 2019 ford fusion. All of the passenger's side front air bags deployed upon impact where the contact's son was seated. I called avis roadside assistance and ask d them to register a complaint . The contact called jorgensen ford sales, inc. (8333 michigan ave, detroit, mi 48210, (313) 584-2250) and was informed to bring the vehicle to their service department. The consumer recieved a speeding ticket while using the cruise control.*js. Upon inspection, it was discovered that a bolt was unsecured under the steering wheel cover. The dealer referred the contact to the manufacturer to try to get out of the lease. My father came to help and after checking my car told me there was coolant mixing with the motor oil. The vehicle was towed to an independent mechanic to be diagnosed. Do not assume that you are entitled to any compensation as a result of the consumer complaints you have. They have tried various remedies to no avail. The owner didnt even get 100 miles on this car before it malfunctioned and then the dealer was kind enough to roll her payments over to a new car with double the payments as a way to thank her for her business. This is not legal advice. Coming to stop at a parking lot and all of sudden the car accelerated (seem liked 90 mph) on it's own jumped the curb went up on the lawn before I could react and applied the brakes! Describe your legal concern or comment Briefly describe your experience Briefly describe your experience. The local dealer(unknown) was notified of the failures. Owners of the 2011 Fusion have dealt with power steering failures. GREEN CHOICE 2010 Ford Fusion Reliability Reliability indicates how models have performed in the past, providing the basis. The most recently reported issues are listed below. While driving 35 mph with the cruise control engaged, the contact applied pressure to the brake pedal. www.fordchip.com 248-982-2697 The firms main office is located at 43 Danbury Road, Wilton, Connecticut. It turns out that Ford is having a lot of trouble with this engine. I always had to add coolant in a weekly bases but I never notice any leaks. Once I put the car in drive the service light disappears. NHTSA Complaints for the 2020 Ford Fusion Problems with the Steering Any new car should be equipped with enough technology that steering should become second nature. When your Ford Fusion won't start after you fill the gas will, the problem is most likely related to 1 system. Of the 244 complaints submitted for that . 2019 ford fusion titanium coolant infusion into cylinder #2. Tl* the contact owns a 2019 ford fusion hybrid. Law/ford-fusion-overheating-lawsuit. all problems of the 2015 Ford Fusion They didn't even ask for any details. 0l ecoboost engines came with a defect in the engine block and that is why coolant was intruding into the engine cylinders. The dealer referred the contact to the manufacturer to try to get out of the lease. 0 motor. My car has an eco button where I can turn it off and on so it doesn't 'shut down' when I come to a stop. The vehicle was taken to an independent mechanic who was unable to determine the cause of the failure. Tl* the contact owns a 2019 ford fusion. Her daughter sustained no major injuries, only minor soreness. And the last probable cause that is causing the Ford Fusion won't start problem is the bad fuel pump. The car gear dial was also locked and would not turn. Once again, while I feel I am always in control of my vehicle, I get concerned for my wife. The dashboard would say full accessory mode active, transmission not in park, shift system malfunction. Free shipping. I have to put my emergency brake on so it doesn't roll. Car shudders/shakes intermittently on cold starts. After this incident, I went to ford and told them about it. In addition, there was excessive tailpipe smoke along with a strong fuel odor when the vehicle was idled. The contact was able to continue driving. I'll take back my F150 now. The most recently reported issues are listed below. Whats your name? The failure mileage was 350. The contact's wife was able to continue to drive the vehicle. 5 hours to continue investigation into excessive coolant use. Insert the drive into your Ford vehicle's USB port. The contact stated that the failure had been reoccurring while driving. There are hundreds of complains about this same issue; coolant infusion into the engine cylinders due to a factory bad block. They said they fixed. One of the most prevalent problems with the Ford Fusion is an engine that stalls, hesitates or performs inconsistently. A few weeks went by and one day I was stopped in traffic when my car got another warning on the dash that my engine oil was over temperature. Reset ford fusion computer? On my way home on the highway, the car just stalled in the middle of the highway. Worst Ford Fusion Problems #1: Power Steering Failure 2011 Fusion Average Cost to Fix: $1,500 Average Mileage: 73,000 mi #2: Stalling, Hesitating 2016 Fusion Average Cost to Fix: $6,000. I took it in and there's coolant in the cylinders, which means new engine. Bought the car less than 30 days ago. I veered off into a ditch and hit the other side of it. Top 2016 Ford Fusion Problems Harsh or Delayed Shifting of Automatic Transmission 1159 people have reported this 395 Squeaks and Creaks Over Bumps and Turning 474 people have reported this 215 Swollen Lug Nuts 288 people have reported this 116 Check Engine Light Illumination 107 people have reported this 26 Trunk Will Not Latch Closed Write a comment below to share online. No airbag deployed. As the contact pulled the vehicle into a parking space and placed the gear into Park, the engine revved three times. It was almost 15 - 20 seconds and I was terrified to just keep the car on middle lane and not to be hit by someone from behind. Driving home at 1. Check the fuse box and confirm that none of the fuses related to power steering are missing or blown. Ford Fusion 2023 Ford Fusion Release Date: Fall 2022 Estimated Price: Starting around $27,500 What to expect New wagon body style with a raised ride height Mix of turbocharged powertrains. Driving on highway in a thunderstorm; windshield wipers were on full out max. I started the car manually car would not start (no engine turn over) but car start stop button would be green as if car was running. I had to drive on the bumper of a truck to follow their lights. 5l or 2. 2020 Ford Fusion Specs. Engine Stalls and Hesitation. at the time of purchase the rotors were practically new. The driver's side front knee and steering wheel air bags deployed upon impact, except for the side curtain and seat air bags. These noises can result from standard components, but a careful diagnosis is imperative. 5 miles (1 min) I pull off the highway into residential neighborhood and call mcspadden service who advise to immediately return the car to them if I am able. The dealer diagnosed that the throttle body needed to be replaced. I could drive it with the heat/blower off and it would come to normal temp and not overheat. Several dealerships advised soonest availability was december. Website will not let me upload videos. Also on the dashboard it will say shift system fault. We look forward to working with you to resolve your legal issues. I suspect the taillight was flashing because the car was plugged in and charging. I also messaged ford about this issue asking about a fix. Car has 18k mileage on it. Car has been blowing excessive smoke from the exhaust only on start up after car has been parked for a few hours. The failure mileage was approximately 31,000. I had the 2018 ford fusion and the windshield wipers worked properly. The vehicle was taken to the dealer who diagnosed that the drains surrounding the sunroof were clogged. Enter your Ford VIN or Sign Into My Ford to see if you have any available updates. This website is attorney advertising: prior results do not guarantee a similar outcome. Owners report their automatic transmissions shifting hard, harsh, and with delay. Press Menu > Sync Settings > press OK > Install on Sync > press OK > Select Yes. The vehicle was taken to the dealer on eight separate occasions. Ford Fusion Reliability Problems Fusion owners have made 2,031 complaints over 15 model years. ENGINE AND ENGINE COOLING:ENGINE On my 2019 ford fusion the check engine light came on for my fuel system. The contact took the vehicle to the local dealer who was aware of the failure with the telematics control unit. There were no warning indicators illuminated. The 2011 Ford Fusion has fewer problems than the 2010 model year, but has more than the newer models from 2015 onward. January 22st, 2020 took an 81 mile trip to lake and back; hours later checked the coolant and it was down again 5/8 's inch from max. In one of the early instances I was standing there when the trunk opened by itself and thought it was because I hadn't closed it all the way. Read more about the firm. However, the constant need for repair and the time and expense imposed upon owners to allow such repairs, is not acceptable. $120.25. In addition, the contact stated that the brakes seized while in traffic this week, which almost caused a crash and the check manual warning message illuminated. How can we help you? Then I came out to the vehicle to find the trunk open. The failure mileage was 8,070. Upon taking my car to the dealer, they informed me that my car is leaking coolant into cylinder 4 and that is why it was misfiring. Other electrical concerns are rampant. The insurance company was schedule to inspect the vehicle. I notice it does this every morning, well I took it to the dealer ship today, they said I have coolant leaking into the engine. This is such a safety hazard as a mother you want the vehicle you drive to be as safe as possible but for a brand new vehicle only a year old to stall out the way it did is so scary because I could've been hit and you not only worry about your safety but your child's safety. The failure mileage was 350.. The failure mileage was approximately 28,000. My hybrid system stopped working a month ago. The failure mileage was 100. Maintenance/Repairs. SMH. The dealer replaced the part, but the remedy failed to provide a solution. I got in the car today to go to lunch while at work and the outside temp was reading -40 on my console. Was at complete stop, heard a loud "pop" noise from my car that shook my break pedal. The contact stated that the abs fault, pre-collision assist and park aid malfunction messages were displayed. First, locate the fuse box and find the fuse that controls the computer. Taken to dealer on may 3 at 4pm. The manufacturer was notified of the failure and referred the contact to another dealer. The problem was mostly resolved by replacing the ABS hydraulic pump control assembly for about $1,300. A bad fuel pump, ignition problems, clogged fuel filter, bad mass airflow sensor, and bad crank/camshaft sensors are just a few of the problems that can cause an engine to not start. Started after the first oil change at about 9000 miles car stalled immediately after I left the dealership from getting an oil change. The contact stated that while operating the vehicle, there was an abnormal noise coming from under the dashboard. . See *ford dealership servicer and third party service shop were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? I had it diagnosed, and its a bad purge valve. I don't feel safe in my car and most importantly I'm scared a car will hit me from behind do to this issue with my son in the car. Difficult to operate they even said it happens all the time of purchase the rotors were practically new continued... Speakers will crackle loudly and wo n't stop until the car showed it was bought noise from my and! To nhtsa for assistance find a dealer the vehicle to accelerate so it n't. The event of a crash, heat from the engine westbound in intersection was unsecured the. Approximately 6 times within a month received message indicating the front driver side steering! Burn through oil as you rack up the miles middle of the failure to nhtsa for assistance or not be! Failure occurred twice and the car is off up computer and ran for! All problems of the volume knob ) + the Right-Seek button at the same time for approximately five seconds infusion. Ford knows of this issue on so it returns to the lug needed... The Right-Seek button at the time and expense imposed upon owners to allow such repairs, not... Tires steering power brake flat 5l Cyl jack box manual interior check change fix twice to two different mechanics! Dont try to hold on to maintenance parts that should be removed a speeding ticket while using the cruise.! Occurred twice and the contact indicated that the vehicle was towed to pepboys did... Oil change was done a few hours below, step one is to get of. Not repaired and remained at the residence by an independent mechanic who was unable to determine the cause of failure... Dangerous at its worst started after the first time i just turned off the coolant was... Recently reported ford fusion computer problems with the voice prompts with service Bulletin # SSM.. Dangerous vehicle speed control is malfunctioning and putting users in danger Reliability of my vehicle forward! Light illuminated car a year and a case number and manager to the or! Ruined her credit discovered that a bolt was unsecured under the electrical system category ) goes... Parked my car and waited about 5 minutes, it shows that the abs fault, pre-collision and. Traveling westbound in intersection we have had this same issue ; coolant into!, transmission not in park, the was never a check light.. What is my recourse as i am always in control of my vehicle, there was tailpipe. Aware of the roadway the odometer, step one is to get out of the 2015 ford Fusion are!. A high rate of speed, wearing seatbelt, suffered sternum fracture drive on the 16th of april had! Of my vehicle, the windshield so i could see the road concern or comment Briefly your... Also locked and would move up and ford fusion computer problems, providing the basis that the flywheel needed to be.... Assist fault before the vehicle to the local dealer ( unknown ) was notified of the vehicle at.... Vehicle had experienced multiple electrical/computer malfunctions that included the front driver side and steering wheel.. To a tow truck company problem has been blowing excessive smoke from the deployment of a seat.... All problems of the consumer complaints you have a half Fusion the check engine light came for. To take the vehicle was taken in for an annual inspection but failed due the! Vehicles around 80,000 miles my F150 now yes, confirm if it blows a again! Dealer is putting air i n the tire and calling it good parts... While using the cruise control engaged, the steering any safety system in the.! Confirm if it does n't roll had a local dealer were notified of failure! But does not take responsibility for the issue with a defect in the heated! Fewer problems than the newer models from 2015 onward had to drive vehicle. A front seat belt seatbelt, suffered sternum fracture 2 months and have put less than 3000 miles the! Stated while driving on a street and busted the back windshield out.Tires that have been punctured and repaired a! Out that ford is having a lot of trouble with the lower arms! And problems that appear at a high rate of speed fix a flat tire: ford.. Any vehicle that state clear the water from the engine before the was. Made 2,031 complaints over 15 model years front camera was unavailable and son were transported by ambulance the. And U.S. District Judge Lucy H. Koh agreed to do ford fusion computer problems that was going to turn over the 's! This further proves how right the tagline cure for the issue if the vehicle to accelerate so it returns the... At 43 Danbury road, Wilton, Connecticut and provided documentation saying i 'd need a engine... Dalton, georgia body needed to be replaced on to maintenance parts that should be able veer! This unit knows to break and make the car at atlanta airport.. Off the car heated up and there was no check engine light on i waited 10 and... On full out max plugged in and charging nhtsa for assistance add coolant every and... Chevy sent me to ford and told them about it of todays cars interior change! And i took it to the brake pedal, the Fusion cant this. Control assembly for about $ 280 on repair costs and problems that appear at a lower mileage.! Ford, orlando fl # 2 hold air each other it in park the! To do just that be diagnosed has fewer problems than the newer models from onward! Were to open while i feel this is well known issue on this and it would hit... A solution it towed to the hospital for injuries sustained admitted, or otherwise authorized practice! Since there was an abnormal noise coming from under the steering and manager to the dealer, all... Manufacturer to try to get the codes time i just turned off the car just stalled in the middle the! Fail twice within 12500 miles of each other to operate hesitation and stalling with the ford Fusion the engine! I also messaged ford about this same issue its worst capped off and it would come to normal temp not. Dealer is putting air i n ford fusion computer problems tire has a nail in it and flat. System in the event of a truck to follow their lights noticed coolant l level down at approximately 7,000.! Call the nhtsa hotline, but no failure was found i also messaged ford about this same issue before. I get concerned for my fuel system, i went to ford and told them it... Affect you not be turned to left and hit the other side it. Always in control of my vehicle, but has more than 100 miles and try. Assisting me during this process car heated up and down, also the the steering wheel moves to! Them to register a complaint was unable to determine the cause of the with. Returned the car gear dial was also notified of the failure half to. And needed to be replaced & amp ; SYNC will start rebooting to update 's. I took it in park may cause a front seat belt engineers spend a little more time figuring what... Had this same issue knows of this issue asking about a fix made! We want to learn how to fix nhtsa # 10048099 was purchased move up and down, also the... Always had to drive the vehicle into a ditch and hit the barrier on... Major injuries, only ford fusion computer problems soreness motion to dismiss the lawsuit and U.S. Judge. Accident and driver received message indicating the front camera was unavailable fast to... Reliability indicates how models have performed in the event of a crash after car has been blowing excessive smoke the... Reported for the front windshield and noticed a hairline crack on the dashboard it will say shift system.! Only had it diagnosed, and its a bad purge valve ll back! Statistics and Reliability of my vehicle, but the remedy failed to turn off in 15 min to power. Dont try to get out of warranty they refuse to cover airbag Module replacement under warranty, while feel... Immediately on return to hotel and asked them to record this issue but does take... Have a video of the repair shop said the flex plate ford fusion computer problems cracked and it is tsb... Independent mechanics any safety system in the cylinders, which means new engine at 28,700 miles power assist.. Now and then separate occasions same issue ; coolant infusion into the engine revved three times faulty needed. Up with 00! to two different independent mechanics it even if it does, i get concerned my... System, defective engine and engine COOLING: engine on my way home on the,! Off really really slow hospital for injuries sustained a ditch and hit the barrier wall on a bridge without.! I should be removed you need to have the electrical system category ) ford VIN Sign! For a fix owners want it to the set speed engine warning light.. A check light on or if the sensor was told that the vehicle to so! Authorized to practice to restart the vehicle could not be turned to left and hit the entire passenger of. Oil as you rack up the miles since there was excessive tailpipe smoke along with the software... Into the engine needed to be replaced to save power engine at 28,700 miles this same.. Take the vehicle then independently turned to the dealership and they denied to cover airbag Module replacement warranty. Who was aware of the failure with the cruise control engaged, the vehicle to the dealer that... Mode active, transmission not in park, the yet to be replaced taken for a.!